Mason Sand for Patios in Edgerton, WI

Wisconsin Rock Supply handles gravel and aggregate delivery in Edgerton, WI for two kinds of buyers: crews building patios and flatwork, and homeowners finishing a driveway or a bed. Traffic bond is the base most of them start with. Under this ground, which sits on lime-rich glacial till capped with silt loam loess, the base you pour onto decides how the surface looks in three years.

Materials for Edgerton Projects

A paver patio fails from the bottom up. The bedding layer spreads under the pavers, and it has to drain and lock at the same time. For Edgerton patios and flatwork, that usually means Mason Sand or Screenings, with a compacted base below it.

Wisconsin suppliers sell stone dust as screenings. It packs hard, so it works as paver and patio bedding and as a top dressing on a drive. Mason sand is the finer choice for brick and block work and for play sand.

Below the bedding, the base does the heavy lifting. Traffic bond, which is also called 3/4 inch traffic bond or 3/4 inch dense graded base, is a crushed dense-graded material that packs hard. It suits driveways, parking pads, and shed and patio bases. Some suppliers here label it road gravel. Order 3/4" Traffic Bond for driveways, parking pads and shed bases.

Where the ground under all of it is soft or clayey, crews start with Breaker Run, a coarse crushed stone with fines that goes down as a heavy sub-base and gets capped with traffic bond. Above a compacted base, 3/4" Crushed Stone handles drainage beds and backfill around foundations and pipe; Wisconsin crews call that clear stone because the fines are screened out.

Ground and Conditions in Edgerton

The failure a thin base shows here is edge settling. Water sits in kettles, marshes and low ground between drumlins and moraines, and slow-draining till holds spring rain and snowmelt near the surface. Put a thin layer of traffic bond under pavers and the edges drop within a season or two.

A thicker bedding layer will not solve it; depth and drainage will. Excavate deep enough to carry a compacted base below the bedding, then give the water somewhere to go. That is where clear stone or drain rock earns its place.

Frost is the other driver. Frost depth runs at least 48 inches for footings under the Uniform Dwelling Code, and 48 to 72 inches under pavement by late winter. Silty and clayey spots heave and soften during the thaw, so compact in lifts and keep fines out of the drainage layer.

Timing matters too. Base, driveway and paver work runs from the end of the spring thaw into late fall. Posted county, town and village roads carry spring weight limits while frost comes out, and frozen ground stops compaction in winter.

Delivery to Edgerton and the Surrounding Area

Order online and pick your material, then choose the quantity. Bulk aggregate is sold by the ton, but most people find it easier to estimate in cubic yards and let the ton figure follow. Multiply the square footage by the depth in feet, divide by 27, and you have your yards.

Bedding sand is a thin layer, so it adds up slower than base. Most Edgerton projects need far more traffic bond than masonry sand, and guessing short on base is the mistake that costs a second delivery.

Wisconsin Rock Supply delivers across Edgerton in Rock County, and to Janesville, Beloit, Evansville, Milton and Clinton. For a patio or flatwork job, have the excavation ready and a clear spot for the truck to dump.

Size Your Order and Get It Delivered

Start with the quantity calculator, enter your square footage and depth, and it will point you at the right tonnage. That is the fastest way to avoid a short load on a patio base. When you have your numbers, order online and Wisconsin Rock Supply will deliver the material to your Edgerton site.